Bronco hard top is beginning to warp really bad and delaminate. Classic problem happening with there and ford still refuses to come up with a real solution. Every day the warping gets worse and I’m just waiting for it to get bad enough so I can take it in and ford actually do something about it. The warping and delaminating also impacts the seals of the hardtop panels on the car. The top also rattles really bad. Absolutely crazy for an expensive car. It’s very obvious that climate and humidity have the largest impact on this issue and STILL they do nothing about it.

On June 22, 2026, my 2025 Ford Bronco caught fire while parked outside a store. The vehicle had been parked for approximately five minutes when the fire began. There were no warning lights, alerts, unusual odors, or other indications of a problem before the incident. The fire and heavy smoke appeared to originate from the center console area near the gear shifter. The flames quickly spread throughout the driver’s side, center console, front passenger area, and the rest of the vehicle’s interior. The entire interior sustained severe fire and heat damage and was substantially melted. The responding fire department advised that temperatures inside the vehicle were well over 300 degrees. Firefighters disconnected the vehicle’s battery, after which the vehicle began to cool. Based on their initial observations, they indicated that the fire appeared to be electrical in nature. The vehicle had recently been filled with gasoline, which made the situation even more dangerous. Fortunately, no one was inside the Bronco, no other vehicles were parked nearby, and the fire department responded quickly. The vehicle has been transported to a repair facility but has not yet been inspected to determine the precise cause of the fire. I am extremely concerned that a nearly new vehicle could suddenly catch fire while turned off and parked, without any warning. This could have occurred while I was driving, with passengers inside, or while the Bronco was parked in my garage. Under those circumstances, the fire could have caused serious injury or death, destroyed my home, or endangered other people and property. I am submitting this complaint because I believe this incident presents a serious public-safety concern. I respectfully request that NHTSA investigate whether other 2025 Ford Bronco owners have experienced similar electrical fires and whether a defect exists that could place drivers, passengers, families, first responders, and the public at risk.

I have a 2025 Ford Bronco Big Bend with 5233 miles. The windshield wipers stopped working. I checked the fuse and the fuse was good. I changed the fuse anyway and the wipers still do not work.

When the vehicle is in "Eco" mode, and an attempt is made to rapidly accelerate in an emergency situation, pressing the accelerator pedal to the floor results in a significant delay before *any* engine response is detected, far beyond what is reasonable for a normal gasoline powered vehicle. In several situations, I was in heavy traffic; traffic in the lane in which I was travelling was relatively slow. I attempted to change lanes into an adjacent lane in which traffic was moving much faster. When traffic allowed, I merged into the faster lane, and pressed the accelerator pedal to the floor. Prior to pressing the accelerator pedal, the vehicle was moving approximately 20 mph. Nothing happened for several seconds, and then the vehicle suddenly accelerated. During the period of non-response, traffic in the faster lane caught up to my vehicle. I am able to reproduce the issue 100%. The dealer's response is that "it's normal" (typical service response) and there was no attempt to investigate. I have driven several identical make/model vehicles belonging to friends, and one dealer vehicle (test drive) and they all exhibit the same issue. There are no warning lamps, errors, codes, or any indication that any system is faulty. The high latency in the throttle control system is clearly an ECU programming issue, and it increases the risk of collision. I have only observed this issue in models of this vehicle with an automatic transmission. I do own an identical model of this vehicle with a manual transmission, and this issue is not present.

Vehicle was parked in a secured location and the back windshield spontaneously broke more likely due to hot weather.